微冻过程中温度波动对猪肉和三文鱼品质影响的评估

Assessment of quality deviation of pork and salmon due to temperature fluctuations during superchilling 微冻过程中温度波动对猪肉和三文鱼品质影响的评估 1 first-author 1 2 2 1 3 corresp Wei CHEN, zjuchenwei@zju.edu.cn Wei CHEN, zjuchenwei@zju.edu.cn zjuchenwei@zju.edu.cn https://ORCID:orcid.org/0000-0002-2373-2437 Department of Food Science and Nutrition, College of Biosystems Engineering and Food Science, Zhejiang University, Hangzhou 310058, China Department of Food Science and Nutrition, College of Biosystems Engineering and Food Science, Zhejiang University, Hangzhou 310058, China 浙江大学生物系统工程与食品科学学院食品科学与营养学系，中国杭州，310058 浙江大学生物系统工程与食品科学学院食品科学与营养学系，中国杭州，310058 Changhong Meiling Co. Ltd., Hefei 230000, China Changhong Meiling Co. Ltd., Hefei 230000, China 长虹美菱股份有限公司，中国合肥，230000 长虹美菱股份有限公司，中国合肥，230000 Ningbo Research Institute, Zhejiang University, Ningbo 315100, China Ningbo Research Institute, Zhejiang University, Ningbo 315100, China 浙江大学宁波研究院，中国宁波，315100 浙江大学宁波研究院，中国宁波，315100 Superchilling is an emerging technology for meat preservation; however, the temperature changes during the process have been commonly ignored. Thus, the effects of temperature fluctuations on meat quality during superchilling are yet to be evaluated. In our study, pork loins and salmon fillets were stored for several days (0, 8, 15, 23, and 30 d) under different temperature fluctuations based on -3.5 ℃ as the target temperature. The results showed that after 15 d of superchilling storage, the values of total volatile basic nitrogen, total viable count, and lipid oxidation were significantly ( P < 0.05) altered in the ±2.0 ℃ fluctuation group compared with the constant temperature group. On the contrary, there was no significant difference in these parameters between the ±1.0 ℃ fluctuation group and the constant temperature group after 30 d of storage. In addition, irregular temperature changes significantly accelerated the modulation of various indicators. In brief, temperature fluctuations and irregular temperature changes accelerated the destruction of muscle structural integrity, increased the water loss, gradually widened the water loss channels, and thereby reduced the edibility by accelerating the spoilage of meat. 目的： 2 本研究以猪里脊肉和三文鱼排为研究对象，就肉品在低温贮藏状态下，因温度变化导致品质劣变，但具体过程不清的问题，通过探究空气温度波动与冲击范围对肉品品质影响的规律，以及蛋白变性和降解与猪肉和三文鱼品质劣变间的联系，发掘可适用于猪肉和三文鱼的低温保鲜技术。 创新点： 2 首次系统探究了冰箱的温度波动在微冻条件下对猪肉与三文鱼品质的影响规律，为冰箱通过控制空间内部温度波动范围提升性能提供了新的理论依据。 方法： 2 以−3.5 °C为目标温度，在不同温度波动条件下，对猪里脊肉和三文鱼片进行贮藏（0、8、15、23和30天），后续通过测定感官、理化与微生物指标，揭示温度波动幅度对肉品品质影响的规律。此外，从细胞组织结构和骨架蛋白等角度，研究温度波动与冲击对猪肉和三文鱼中蛋白质变性与降解的影响。 结论： 2 微冻贮藏15天后，与恒温组相比，±2.0 °C波动组中猪里脊肉和三文鱼片中总挥发性碱性氮、菌落总数和脂质氧化发生显著变化（ P < 0.05）。而±1.0 °C波动组与恒温组在贮藏30天后各项参数均无显着差异。此外，普通冰箱不规则的温度波动加速了各项指标的变化（ P < 0.05）。综上所述，温度波动和不规则的温度变化会加速破坏肉组织结构的完整性，增加滴水损失，进而逐渐拓宽肉品失水通道，最终增快肉品腐败变质速度。 Pork Salmon Superchilling Temperature fluctuation Meat quality 猪肉 三文鱼 微冻 温度波动 肉品品质 1 Introduction 1 Meat is an important part of the human diet. Pork is representative of red meat and occupies a major position in the global market of meat products ( Woodet al., 1999 Wood et al., 1999 ). Salmon has become progressively more popular among fish in recent years because of its rich nutrition and delicious taste ( Haghiri, 2016 Haghiri, 2016 ). The various nutrients in meat provide an ideal environment for the growth and propagation of common food spoilage organisms ( Yanget al., 2017 Yang et al., 2017 ). If fresh meat is not processed appropriately, it can easily spoil due to microorganisms, resulting in poor meat quality ( Fidalgo et al., 2021 Fidalgo et al., 2021 ). Therefore, quality and safety assurance are necessary for the development of the meat industry ( Xieet al., 2016 Xie et al., 2016 ; Chenget al., 2017 Cheng et al., 2017 ). Temperature is a crucial factor in the meat supply chain. Processes such as the denaturation and degradation of heat-labile muscle proteins, lipid oxidation, and protease reactions are sensitive to temperature changes, which can further lead to the poor quality of meats ( Duun and Rustad, 2008 Duun and Rustad, 2008 ). "Superchilling" was first introduced in 1920 and was defined as the temperature zone where the storage temperature of food is dropped to 1–2 ℃ below its initial freezing point ( Duun and Rustad, 2007 Duun and Rustad, 2007 ). This value is between the two temperature zones of traditional refrigeration and freezing ( Zhouet al., 2010 Zhou et al., 2010 ). With the continuous improvement of superchilling technology, the related cold storage system is becoming more advanced to improve the shelf-life of meats. One study controlled the temperatures at -‍1 ℃ to -3 ℃ using refrigerated chambers for the preservation of salmon fillets and seabass ( Changet al., 1998 Chang et al., 1998 ). Compared with -2 ℃, superchilling at -3 ℃ extended the shelf-life of pork as well as maintained better meat quality, which was later measured by the total viable count, total volatile basic nitrogen (TVB-N), and thiobarbituric acid reactive substances (TBARSs) ( Ding et al., 2020 Ding et al., 2020 ). Superchilling was reported to minimize biochemical degradation, protein denaturation, and structural damage in Atlantic salmon compared with frozen storage ( Gallart-Jornetet al., 2007 Gallart-Jornet et al., 2007 ). Superchilling was reported to improve the shelf-life of foods by approximately 1.5–4.0 times compared to traditional refrigeration ( Kaaleet al., 2011 Kaale et al., 2011 ). The temperature control capability of superchilling equipment on the market shows variation. The associated challenges prompt the standardization of the thermal process and determination of the optimal degree of superchilling for different product groups to adequately improve shelf-life ( Banerjee and Maheswarappa, 2019 Banerjee and Maheswarappa, 2019 ). Most of the existing research has focused on the effect of a single temperature (such as -3 ℃) on meat quality ( Yeet al., 2020 Ye et al., 2020 ). Nowadays, refrigerators and other low-temperature storage devices sold in the market still feature temperature changes within the storage space, which is usually ignored by merchants and consumers alike ( Derens-Bertheauet al., 2015 Derens-Bertheau et al., 2015 ; Khan et al., 2017 Khan et al., 2017 ). Our study is mainly focused on temperature fluctuations during long-term superchilling and their impact on the quality deterioration of pork and salmon. The results provide a new theoretical basis for reducing the temperature fluctuations in low-temperature storage equipment, in order to improve the meat quality during cold storage. 2 Results and discussion 1 2.1 Design of temperature fluctuations 2 During the freezing process, the core temperature of meat dropped rapidly at the initial stage of freezing, followed by a plateau period, after which the temperature dropped continuously. The temperature range of the plateau period is the freezing point of the meat. According to previous studies, the initial freezing points of pork loins and salmon fillets are about -1.0 ℃ and -1.4 ℃, respectively ( Duun and Rustad, 2008 Duun and Rustad, 2008 ; Duunet al., 2008 Duun et al., 2008 ; Pomponio and Ruiz-Carrascal, 2017 Pomponio and Ruiz-Carrascal, 2017 ). Superchilling storage usually controls the temperature of food at 1–‍2 ℃ below the initial freezing point. In our experiment, -3.5 ℃ was selected as the temperature for the superchilling storage of pork and salmon. The temperature inside a refrigerator shows complex fluctuations. When the superchilling temperature of an ordinary refrigerator was set to -3.5 ℃, the temperature changes in the central area of refrigerator were observed ( Fig. 1 Fig. 1 a). These temperature changes were dominated by fluctuations. In our study, the refrigerators had been remodeled to obtain only the temperature fluctuations during storage. The constant temperature space was assembled in a place where the temperature fluctuations were minimized, such that the internal temperature changes were kept within ±0.3 ℃ ( Fig. 1 Fig. 1 b). Subsequently, the internal temperature of the refrigerator was adjusted so that the temperature fluctuations stabilized, and the integral average temperature value was -3.5 ℃. The temperature fluctuations of (-3.5±1.0) ℃ and (-3.5±2.0) ℃ were shown in Figs. 1c 1c and 1d 1d , respectively. The temperature changes in the center and surface of pork and salmon under different temperature conditions were shown in Fig. S1. 2.2 Effects of temperature fluctuations on meat quality indicators 2 TVB-N generally refers to the basic nitrogen-containing substances such as volatile ammonia and amines, which are produced by the decomposition of proteins due to the joint interaction of muscle enzymes and bacteria during meat storage ( Olafsdóttiret al., 1997 Olafsdóttir et al., 1997 ). The changes in TVB-N in the different study groups during superchilling were shown in Fig. 2 Fig. 2 . In general, the acceptable limit of TVB-N value for fresh meat during cold storage is 15 mg/100 g ( Zhanget al., 2011 Zhang et al., 2011 ; Fidalgo et al., 2021 Fidalgo et al., 2021 ). The average TVB-N of pork increased gradually from Day 0 (8.87 mg/100 g). From Day 8, the average TVB-N values of the constant temperature group and the ±1.0 ℃ fluctuation group were significantly altered compared to the other groups. On Day 30, the mean TVB-N value of the constant temperature group was 11.55 mg/100 g, while the value for the ±2.0 ℃ fluctuation group was 14.23 mg/100 g. The TVB-N of the control group exceeded 15 mg/100 g on Day 25. This parameter did not exceed 15 mg/100 g for the other three groups at Day 30; however, there was a significant difference between the ±2.0 ℃ fluctuation group and the constant temperature group ( P < 0.05). The average TVB-N of salmon gradually increased from Day 0 (10.03 mg/100 g), and the differences compared to the experimental groups were not clear on Day 8. The TVB-N values of the control group and the ±2.0 ℃ fluctuation group exceeded 15 mg/100 g on Days 16 and 23, respectively, accompanied by the clear smell of ammonia. On Day 30, the average value of the constant temperature group was 13.53 mg/100 g, and there was no significant difference between the constant temperature group and the ±1.0 ℃ fluctuation group ( P > 0.05). On Day 30, the average TVB-N value of the control group of salmon was 20.53 mg/100 g, which was much higher than that of the pork control group (15.52 mg/100 g). This was because salmon fillet had a lower freezing point than pork loin. The temperature in the superchilling area of the ordinary refrigerator was irregular, and the temperature showed great fluctuation, which could easily be above the freezing point of salmon, greatly reducing the amount of ice crystals in salmon fillets. Pork loins had a higher degree of ice crystallization than salmon fillets. Another reason for the above phenomenon is that salmon has more free nitrogen than pork. Therefore, the TVB-N value increased more slowly in pork loins. The observed TVB-N values were consistent with the previously reported growth trend ( Cordoba et al., 1994 Cordoba et al., 1994 ). The results showed that the irregular temperature changes had a great influence on the TVB-N value during superchilling storage. With the increase of storage time, ±2.0 ℃ fluctuations induced the significant increase of TVB-N value, while ±1.0 ℃ fluctuations did not significantly change the TVB-N value compared with the constant temperature group. The growth and reproduction of microorganisms can lead to the spoilage of meat products. Total viable count (TVC) is a common indicator for evaluating the quality and shelf-life of meat products. The changes of TVC in pork and salmon during superchilling were shown in Fig. 3 Fig. 3 . In general, the acceptable limit of TVC value for fresh meat during storage is 1×10 6 colony forming units per gram (CFU/g) ( Coombset al., 2017 Coombs et al . , 2017 ). The average TVC of pork gradually increased from Day 0 (3.87 lgCFU/g). From Day 8, the TVC values of the ±2.0 ℃ fluctuation group and the control group were significantly higher compared to the other two groups ( P < 0.05). The control group exceeded 6 lgCFU/g on Day 27. The average TVC of salmon increased gradually from Day 0 (3.41 lgCFU/g). The control group and the ±2.0 ℃ fluctuation group exceeded 6 lgCFU/g on Days 16 and 26, respectively. There was no significant difference between the constant temperature group and the ±1.0 ℃ fluctuation group ( P > 0.05). The results showed that temperature changes had a great influence on the variation in TVC values. As the time passed, the ordinary refrigerator and ±2.0 ℃ fluctuations significantly promoted the increase of TVC, while ±1.0 ℃ fluctuations did not alter the TVC significantly compared with the constant temperature group. Besides, the TVC of salmon was initially lower than that of pork, but it eventually exceeded it. It was speculated that the high fat and protein contents in salmon were more conducive to the growth and reproduction of microorganisms ( Fernández et al., 2009 Fernández et al., 2009 ). The degree of ice crystallization in the control salmon fillets was lower than that in the pork loins, and therefore the TVC value increased more rapidly in salmon fillets. At the same time, the growth trend of TVC in each group was consistent with the TVB-N level. Considering the results of TVC and TVB-N, the shelf-life of pork of the constant temperature group and the ±1.0 ℃ fluctuation group was approximately 36–39 d, whereas the shelf-life of salmon was approximately 33–35 d. On the other hand, the shelf-life of pork of the ±2.0 ℃ fluctuation group was approximately 29–32 d, while the shelf-life of salmon was approximately 27–30 d. TBARS is widely used to determine the degree of oxidative rancidity of fats in foods, especially fats in meat and aquatic products ( Campoet al., 2006 Campo et al., 2006 ). An increased TBARS value was mainly associated with the auto-oxidation and enzymatic hydrolysis of lipids ( Domínguezet al., 2019 Domínguez et al., 2019 ). The changes of TBARS in pork and salmon during superchilling were shown in Fig. 4 Fig. 4 . The TBARSs of pork and salmon gradually increased, starting from 0.17 and 0.43 mg/kg on Day 0, respectively. From Day 15, the difference between the ±2.0 ℃ fluctuation group and the constant temperature group remained significant ( P < 0.05). The constant temperature groups of pork and salmon had no significant difference compared to both ±1.0 ℃ fluctuation groups. Salmon consistently had higher TBARS values than pork. This is because salmon has higher fat content and is more prone to oxidation under superchilling conditions ( Thanonkaew et al., 2006 Thanonkaew et al., 2006 ). The results showed that irregular temperature changes in the ordinary refrigerator and that with ±2.0 ℃ temperature fluctuations accelerated the lipid oxidation in pork and salmon during storage, which was consistent with the results of TVB-N and TVC. Drip loss, as one of the indicators to evaluate the water retention capacity of meat, is an important parameter for evaluating meat quality ( Buenoet al., 2013 Bueno et al., 2013 ). The changes in drip loss in pork and salmon during superchilling were shown in Table S1. Drip loss was more severe in pork compared to salmon because of its higher free water content. On Day 30, drip loss in the control group was significantly higher than those in the constant temperature group and the ±1.0 ℃ fluctuation group ( P < 0.05). According to our results, it was speculated that irregular temperature changes and ±2.0 ℃ temperature fluctuations caused the repeated freeze and thaw cycles of ice crystals in the meat and reduced the ratio of ice formed in pork and salmon. At the same time, the repeated formation of intracellular ice crystals could pierce the cell membrane, reduce the water retention capacity of meat, and subsequently aggravate the drip loss ( Kaaleet al., 2014 Kaale et al., 2014 ). The changes in pH of pork and salmon during superchilling were shown in Fig. S2. In our study, the average pH of pork changed from 5.89 (on Day 0) to 5.38–5.55 (on Day 15), and then gradually increased. The average pH of salmon changed from 6.57 (on Day 0) to 6.31 (on Day 15), and then gradually increased. This is because in the initial storage period, the glycogen and adenosine triphosphate (ATP) in the meat are decomposed to produce acidic substances (such as lactic acid), which lowers the pH value. With the increase of storage time, the protein in meat is decomposed by the action of microorganisms and produces alkaline substances, which leads to the rise of pH value ( Scheffler and Gerrard, 2007 Scheffler and Gerrard, 2007 ). After Day 23, there was a significant difference in pH between the control group and the constant temperature group ( P < 0.05). It was implied that irregular temperature changes accelerated the spoilage of meat, which was manifested as an accelerated pH value. In addition, it was speculated that pH value of the salmon control group first increased and then decreased from Day 23 to Day 30. This was due to more pronounced spoilage, the denaturation of myofibril proteins, and the release of hydrogen ions, which led to a pH drop in the salmon control group towards the end of storage ( Zhang and Ertbjerg, 2019 Zhang and Ertbjerg, 2019 ). Color is an important quality indicator of fresh meat, which directly affects the consumer acceptance. Lightness value ( L * ), redness value ( a * ), and yellowness value ( b * ) are three important parameters for evaluating color ( Holman et al., 2016 Holman et al., 2016 ). Sarcoplasmic protein solubility declines with decreasing pH, which contributes to a paler pork color. In addition, a slight water loss can enhance the lightness of pork. The proper coloration of salmon is dependent on the contents of astaxanthin and cantaxanthin. The flesh color should be deep red/orange and can be evenly distributed along the salmon fillet. The altered physical state of salmon myofibrils can affect the light scattering properties and lead to color changes ( Erikson and Misimi, 2008 Erikson and Misimi, 2008 ). The changes of meat color in pork and salmon during superchilling were shown in Fig. S3. The L * value of pork fluctuated from 36.89 to 47.03, the a * value changed from 4.20 to 6.89, and the b * value increased from 12.13 to 17.85. In the case of salmon, the L * value fluctuated from 33.28 to 45.24, while the a * value fluctuated from 13.45 to 18.62, and the b * value rose from 16.51 to 22.64. With the passing of storage time, the color changes of pork and salmon were not clear, and the differences among the groups were large. It was speculated that temperature changes under superchilling storage had no significant effect on the color of fresh meat, which is in agreement with previous research ( Rosenvold and Wiklund, 2011 Rosenvold and Wiklund, 2011 ). 2.3 Effects of temperature fluctuations on the myofibril protein changes 2 During meat storage, proteins in the muscle become denatured, expose the hydrophobic inner core, and increase the surface hydrophobicity. The binding efficiency of bromophenol blue (BPB) and protein hydrophobic residues reflects the hydrophobicity of meat surface protein ( Liet al., 2019 Li et al., 2019 ). The changes of BPB bound in pork and salmon during superchilling were shown in Fig. S4. The average surface hydrophobicity of pork and salmon in the constant temperature group gradually increased from Day 0 (32.26 and 44.44 μg, respectively) to Day 30 (79.79 and 94.57 μg, respectively). The constant temperature group was significantly different from the control group on Day 15 ( P < 0.05), and it was also significantly different from the ±2.0 ℃ fluctuation group on Day 23 ( P < 0.05). Greater surface hydrophobicity means a higher degree of protein denaturation. The results confirmed that irregular temperature changes and ±2.0 ℃ temperature fluctuations accelerated the protein degradation in pork and salmon. During the superchilling storage of muscle, the structural integrity of myofibrils can be destroyed and myofibrils can break into small fragments (consisting of several sarcomeres), which is measured by the myofibril fragmentation index (MFI). The changes of MFI in pork and salmon during superchilling were shown in Fig. S5. The average MFI of pork and salmon in the constant temperature group gradually increased from Day 0 (50.73 and 67.97, respectively) to Day 30 (83.81 and 101.63, respectively). The constant temperature group was significantly different from the control group on Day 15 ( P < 0.05), and it was also significantly different from the ±2.0 ℃ fluctuation group on Day 23 ( P < 0.05). During the post-mortem storage of meat, myosin and actin degradations are important reasons for the increase of MFI ( Qianet al., 2020 Qian et al., 2020 ; Xionget al., 2020 Xiong et al., 2020 ). Our results confirmed that irregular temperature changes and ±2.0 ℃ temperature fluctuations accelerated the myofibrillar protein degradation towards the end of storage, which was consistent with the results of BPB bound. 2.4 Evaluation of the structural variation of muscle 2 The microstructure of cross-section of pork and salmon muscles was visualized by light microscopy (LM) and scanning electron microscopy (SEM) during superchilling storage (Figs. S6 and 5). The images of fresh samples on Day 0 showed that the muscle cells were uniform in size, rigid in structure, and the intercellular gaps were small and uniform. After 15 d of storage, the intercellular gaps slightly increased in different groups. After 30 d of storage, the intercellular gaps in the pork and salmon increased significantly, while they were still relatively tight in the constant temperature group. In comparison, the irregular temperature changes and ±2.0 ℃ temperature fluctuations had a greater degree of compression deformation, such as scattered, twisted, and even partially broken myofibrils, which further accelerated the spoilage of meat. During superchilling storage, ice crystals firstly form between the muscle cells. With the increase of storage time, the gaps between myofibrils gradually enlarge, and the muscle fibers break down, which makes the tissue structure of muscle sparser. The formation of intracellular and extracellular ice crystals damages the integrity of muscle tissue and promotes microstructural deterioration ( Wuet al., 2014 Wu et al., 2014 ). At the same time, the degradation of myofibril protein (including cytoskeletal proteins) during the enzymatic reaction may lead to the destruction of cytoskeleton and the removal of structural connections between muscle fibers ( Syamaladeviet al., 2012 Syamaladevi et al., 2012 ). This phenomenon further leads to the formation of wider water loss channels, which could be seen from the muscle microstructure. This result was consistent with the results of myofibril protein changes discussed in Section 2.3. 3 Conclusions 1 In summary, this study uncovered the impact of temperature fluctuations and irregular temperature changes on the quality deviation of pork and salmon during superchilling storage. Among the studied groups, the irregular temperature change and ±2.0 ℃ temperature fluctuation groups exhibited significant increases of TVB-N, TVC, and TBARS than the other indicators after 30 d of superchilling storage. Further investigation showed that temperature changes around the freezing point of meat affected the formation of ice crystals, which accelerated the degradation and denaturation of myofibrillar proteins and thereby impaired the structural integrity of the muscle. Furthermore, the number of water loss channels of muscles also increased and they gradually widened with the increase of storage time. These deformations accelerated the spoilage of meat. Overall, the results highlighted the importance of knowledge on the "proper uses of superchilling temperature for storing meat products, especially pork and salmon." Materials and methods 1 Detailed methods are provided in the electronic supplementary materials of this paper. References Banerjee R , Maheswarappa NB , 2019 . Superchilling of muscle foods: potential alternative for chilling and freezing . Crit Rev Food Sci Nutr , 59 ( 8 ): 1256 - 1263 . https://doi.org/10.1080/10408398.2017.1401975 https://doi.org/10.1080/10408398.2017.1401975 Superchilling of muscle foods: potential alternative for chilling and freezing Bueno M , Resconi VC , Campo MM , et al. , 2013 . Effect of freezing method and frozen storage duration on odor-active compounds and sensory perception of lamb . Food Res Int , 54 ( 1 ): 772 - 780 . https://doi.org/10.1016/j.foodres.2013.08.003 https://doi.org/10.1016/j.foodres.2013.08.003 Effect of freezing method and frozen storage duration on odor-active compounds and sensory perception of lamb Campo MM , Nute GR , Hughes SI , et al. , 2006 . Flavour perception of oxidation in beef . Meat Sci , 72 ( 2 ): 303 - 311 . https://doi.org/10.1016/j.meatsci.2005.07.015 https://doi.org/10.1016/j.meatsci.2005.07.015 Flavour perception of oxidation in beef Chang KLB , Chang JJ , Shiau CY , et al. , 1998 . Biochemical, microbiological, and sensory changes of sea bass ( Lateolabrax japonicus ) under partial freezing and refrigerated storage . J Agric Food Chem , 46 ( 2 ): 682 - 686 . https://doi.org/10.1021/jf970622c https://doi.org/10.1021/jf970622c Biochemical, microbiological, and sensory changes of sea bass(Lateolabrax japonicus)under partial freezing and refrigerated storage Cheng L , Sun DW , Zhu Z , et al. , 2017 . Emerging techniques for assisting and accelerating food freezing processes: a review of recent research progresses . Crit Rev Food Sci Nutr , 57 ( 4 ): 769 - 781 . https://doi.org/10.1080/10408398.2015.1004569 https://doi.org/10.1080/10408398.2015.1004569 Emerging techniques for assisting and accelerating food freezing processes: a review of recent research progresses Coombs CEO , Holman BWB , Friend MA , et al. , 2017 . Long-term red meat preservation using chilled and frozen storage combinations: a review . Meat Sci , 125 : 84 - 94 . https://doi.org/10.1016/j.meatsci.2016.11.025 https://doi.org/10.1016/j.meatsci.2016.11.025 Long-term red meat preservation using chilled and frozen storage combinations: a review Cordoba JJ , Antequera T , Garcia C , et al. , 1994 . Evolution of free amino acids and amines during ripening of Iberian cured ham . J Agric Food Chem , 42 ( 10 ): 2296 - 2301 . https://doi.org/10.1021/jf00046a040 https://doi.org/10.1021/jf00046a040 Evolution of free amino acids and amines during ripening of Iberian cured ham Derens-Bertheau E , Osswald V , Laguerre O , et al. , 2015 . Cold chain of chilled food in France . Int J Refrig , 52 : 161 - 167 . https://doi.org/10.1016/j.ijrefrig.2014.06.012 https://doi.org/10.1016/j.ijrefrig.2014.06.012 Cold chain of chilled food in France Ding DM , Zhou CY , Ge XY , et al. , 2020 . The effect of different degrees of superchilling on shelf life and quality of pork during storage . J Food Process Preserv , 44 ( 4 ): e14394 . https://doi.org/10.1111/jfpp.14394 https://doi.org/10.1111/jfpp.14394 The effect of different degrees of superchilling on shelf life and quality of pork during storage Domínguez R , Pateiro M , Gagaoua M , et al. , 2019 . A comprehensive review on lipid oxidation in meat and meat products . Antioxidants , 8 ( 10 ): 429 . https://doi.org/10.3390/antiox8100429 https://doi.org/10.3390/antiox8100429 A comprehensive review on lipid oxidation in meat and meat products Duun AS , Rustad T , 2007 . Quality changes during superchilled storage of cod ( Gadus morhua ) fillets . Food Chem , 105 ( 3 ): 1067 - 1075 . https://doi.org/10.1016/j.foodchem.2007.05.020 https://doi.org/10.1016/j.foodchem.2007.05.020 Quality changes during superchilled storage of cod(Gadus morhua)fillets Duun AS , Rustad T , 2008 . Quality of superchilled vacuum packed Atlantic salmon ( Salmo salar ) fillets stored at - 1 . 4 and - 3 .6 ℃. Food Chem , 106 ( 1 ): 122 - 131 . https://doi.org/10.1016/j.foodchem.2007.05.051 https://doi.org/10.1016/j.foodchem.2007.05.051 Quality of superchilled vacuum packed Atlantic salmon (Salmo salar) fillets stored at - Duun AS , Hemmingsen AKT , Haugland A , et al. , 2008 . Quality changes during superchilled storage of pork roast . LWT-Food Sci Technol , 41 ( 10 ): 2136 - 2143 . https://doi.org/10.1016/j.lwt.2008.02.001 https://doi.org/10.1016/j.lwt.2008.02.001 Quality changes during superchilled storage of pork roast Erikson U , Misimi E , 2008 . Atlantic salmon skin and fillet color changes effected by perimortem handling stress, rigor mortis, and ice storage . J Food Sci , 73 ( 2 ): C50 - C59 . https://doi.org/10.1111/j.1750-3841.2007.00617.x https://doi.org/10.1111/j.1750-3841.2007.00617.x Atlantic salmon skin and fillet color changes effected by perimortem handling stress, rigor mortis, and ice storage Fernández K , Aspe E , Roeckel M , 2009 . Shelf-life extension on fillets of Atlantic Salmon ( Salmo salar ) using natural additives, superchilling and modified atmosphere packaging . Food Control , 20 ( 11 ): 1036 - 1042 . https://doi.org/10.1016/j.foodcont.2008.12.010 https://doi.org/10.1016/j.foodcont.2008.12.010 Shelf-life extension on fillets of Atlantic Salmon (Salmo salar) using natural additives, superchilling and modified atmosphere packaging Fidalgo LG , Pinto CA , Delgadillo I , et al. , 2021 . Hyperbaric storage of vacuum-packaged fresh Atlantic salmon ( Salmo salar ) loins by evaluation of spoilage microbiota and inoculated surrogate-pathogenic microorganisms . Food Eng Rev , 13 ( 3 ): 651 - 659 . https://doi.org/10.1007/s12393-020-09275-4 https://doi.org/10.1007/s12393-020-09275-4 Hyperbaric storage of vacuum-packaged fresh Atlantic salmon (Salmo salar) loins by evaluation of spoilage microbiota and inoculated surrogate-pathogenic microorganisms Gallart-Jornet L , Rustad T , Barat JM , et al. , 2007 . Effect of superchilled storage on the freshness and salting behaviour of Atlantic salmon ( Salmo salar ) fillets . Food Chem , 103 ( 4 ): 1268 - 1281 . https://doi.org/10.1016/j.foodchem.2006.10.040 https://doi.org/10.1016/j.foodchem.2006.10.040 Effect of superchilled storage on the freshness and salting behaviour of Atlantic salmon (Salmo salar) fillets Haghiri M , 2016 . Consumer choice between food safety and food quality: the case of farm-raised Atlantic salmon . Foods , 5 ( 2 ): 22 . https://doi.org/10.3390/foods5020022 https://doi.org/10.3390/foods5020022 Consumer choice between food safety and food quality: the case of farm-raised Atlantic salmon Holman BWB , Mao YW , Coombs CEO , et al. , 2016 . Relationship between colorimetric (instrumental) evaluation and consumer-defined beef colour acceptability . Meat Sci , 121 : 104 - 106 . https://doi.org/10.1016/j.meatsci.2016.05.002 https://doi.org/10.1016/j.meatsci.2016.05.002 Relationship between colorimetric (instrumental) evaluation and consumer-defined beef colour acceptability Kaale LD , Eikevik TM , Rustad T , et al. , 2011 . Superchilling of food: a review . J Food Eng , 107 ( 2 ): 141 - 146 . https://doi.org/10.1016/j.jfoodeng.2011.06.004 https://doi.org/10.1016/j.jfoodeng.2011.06.004 Superchilling of food: a review Kaale LD , Eikevik TM , Rustad T , et al. , 2014 . Changes in water holding capacity and drip loss of Atlantic salmon ( Salmo salar ) muscle during superchilled storage . LWT-Food Sci Technol , 55 ( 2 ): 528 - 535 . https://doi.org/10.1016/j.lwt.2013.10.021 https://doi.org/10.1016/j.lwt.2013.10.021 Changes in water holding capacity and drip loss of Atlantic salmon (Salmo salar) muscle during superchilled storage Khan MIH , Afroz HMM , Karim MA , 2017 . Effect of PCM on temperature fluctuation during the door opening of a household refrigerator . Int J Green Energy , 14 ( 4 ): 379 - 384 . https://doi.org/10.1080/15435075.2016.1261705 https://doi.org/10.1080/15435075.2016.1261705 Effect of PCM on temperature fluctuation during the door opening of a household refrigerator Li FF , Wang B , Liu Q , et al. , 2019 . Changes in myofibrillar protein gel quality of porcine longissimus muscle induced by its structural modification under different thawing methods . Meat Sci , 147 : 108 - 115 . https://doi.org/10.1016/j.meatsci.2018.09.003 https://doi.org/10.1016/j.meatsci.2018.09.003 Changes in myofibrillar protein gel quality of porcine longissimus muscle induced by its structural modification under different thawing methods Olafsdóttir G , Martinsdóttir E , Oehlenschläger J , et al. , 1997 . Methods to evaluate fish freshness in research and industry . Trends Food Sci Technol , 8 ( 8 ): 258 - 265 . https://doi.org/10.1016/s0924-2244(97)01049-2 https://doi.org/10.1016/s0924-2244(97)01049-2 Methods to evaluate fish freshness in research and industry Pomponio L , Ruiz-Carrascal J , 2017 . Oxidative deterioration of pork during superchilling storage . J Sci Food Agric , 97 ( 15 ): 5211 - 5215 . https://doi.org/10.1002/jsfa.8403 https://doi.org/10.1002/jsfa.8403 Oxidative deterioration of pork during superchilling storage Qian SY , Li X , Wang H , et al. , 2020 . Contribution of calpain to protein degradation, variation in myowater properties and the water-holding capacity of pork during postmortem ageing . Food Chem , 324 : 126892 . https://doi.org/10.1016/j.foodchem.2020.126892 https://doi.org/10.1016/j.foodchem.2020.126892 Contribution of calpain to protein degradation, variation in myowater properties and the water-holding capacity of pork during postmortem ageing Rosenvold K , Wiklund E , 2011 . Retail colour display life of chilled lamb as affected by processing conditions and storage temperature . Meat Sci , 88 ( 3 ): 354 - 360 . https://doi.org/10.1016/j.meatsci.2011.01.006 https://doi.org/10.1016/j.meatsci.2011.01.006 Retail colour display life of chilled lamb as affected by processing conditions and storage temperature Scheffler TL , Gerrard DE , 2007 . Mechanisms controlling pork quality development: the biochemistry controlling postmortem energy metabolism . Meat Sci , 77 ( 1 ): 7 - 16 . https://doi.org/10.1016/j.meatsci.2007.04.024 https://doi.org/10.1016/j.meatsci.2007.04.024 Mechanisms controlling pork quality development: the biochemistry controlling postmortem energy metabolism Syamaladevi RM , Manahiloh KN , Muhunthan B , et al. , 2012 . Understanding the influence of state/phase transitions on ice recrystallization in Atlantic salmon ( Salmo salar ) during frozen storage . Food Biophys , 7 ( 1 ): 57 - 71 . https://doi.org/10.1007/s11483-011-9243-y https://doi.org/10.1007/s11483-011-9243-y Understanding the influence of state/phase transitions on ice recrystallization in Atlantic salmon (Salmo salar) during frozen storage Thanonkaew A , Benjakul S , Visessanguan W , et al. , 2006 . The effect of metal ions on lipid oxidation, colour and physicochemical properties of cuttlefish ( Sepia pharaonis ) subjected to multiple freeze-thaw cycles . Food Chem , 95 ( 4 ): 591 - 599 . https://doi.org/10.1016/j.foodchem.2005.01.040 https://doi.org/10.1016/j.foodchem.2005.01.040 The effect of metal ions on lipid oxidation, colour and physicochemical properties of cuttlefish (Sepia pharaonis) subjected to multiple freeze-thaw cycles Wood JD , Enser M , Fisher AV , et al. , 1999 . Manipulating meat quality and composition . Proc Nutr Soc , 58 ( 2 ): 363 - 370 . https://doi.org/10.1017/s0029665199000488 https://doi.org/10.1017/s0029665199000488 Manipulating meat quality and composition Wu CH , Yuan CH , Ye XQ , et al. , 2014 . A critical review on superchilling preservation technology in aquatic product . J Integr Agric , 13 ( 12 ): 2788 - 2806 . https://doi.org/10.1016/s2095-3119(14)60841-8 https://doi.org/10.1016/s2095-3119(14)60841-8 A critical review on superchilling preservation technology in aquatic product Xie A , Sun DW , Zhu ZW , et al. , 2016 . Nondestructive measurements of freezing parameters of frozen porcine meat by NIR hyperspectral imaging . Food Bioprocess Technol , 9 ( 9 ): 1444 - 1454 . https://doi.org/10.1007/s11947-016-1766-2 https://doi.org/10.1007/s11947-016-1766-2 Nondestructive measurements of freezing parameters of frozen porcine meat by NIR hyperspectral imaging Xiong GY , Fu XY , Pan DM , et al. , 2020 . Influence of ultrasound-assisted sodium bicarbonate marination on the curing efficiency of chicken breast meat . Ultrason Sonochem , 60 : 104808 . https://doi.org/10.1016/j.ultsonch.2019.104808 https://doi.org/10.1016/j.ultsonch.2019.104808 Influence of ultrasound-assisted sodium bicarbonate marination on the curing efficiency of chicken breast meat Yang Q , Sun DW , Cheng WW , 2017 . Development of simplified models for nondestructive hyperspectral imaging monitoring of TVB-N contents in cured meat during drying process . J Food Eng , 192 : 53 - 60 . https://doi.org/10.1016/j.jfoodeng.2016.07.015 https://doi.org/10.1016/j.jfoodeng.2016.07.015 Development of simplified models for nondestructive hyperspectral imaging monitoring of TVB-N contents in cured meat during drying process Ye K , Ding D , Zhu X , et al. , 2020 . Modified atmosphere packaging with a small change in gas ratio could maintain pork quality during -3 ℃ storage . Food Control , 109 : 106943 . https://doi.org/10.1016/j.foodcont.2019.106943 https://doi.org/10.1016/j.foodcont.2019.106943 Modified atmosphere packaging with a small change in gas ratio could maintain pork quality during -3 ℃ storage Zhang LN , Li X , Lu W , et al. , 2011 . Quality predictive models of grass carp ( Ctenopharyngodon idellus ) at different temperatures during storage . Food Control , 22 ( 8 ): 1197 - 1202 . https://doi.org/10.1016/j.foodcont.2011.01.017 https://doi.org/10.1016/j.foodcont.2011.01.017 Quality predictive models of grass carp (Ctenopharyngodon idellus) at different temperatures during storage Zhang YM , Ertbjerg P , 2019 . On the origin of thaw loss: relationship between freezing rate and protein denaturation . Food Chem , 299 : 125104 . https://doi.org/10.1016/j.foodchem.2019.125104 https://doi.org/10.1016/j.foodchem.2019.125104 On the origin of thaw loss: relationship between freezing rate and protein denaturation Zhou GH , Xu XL , Liu Y , 2010 . Preservation technologies for fresh meat ‒ a review . Meat Sci , 86 ( 1 ): 119 - 128 . https://doi.org/10.1016/j.meatsci.2010.04.033 https://doi.org/10.1016/j.meatsci.2010.04.033 Preservation technologies for fresh meat ‒ a review Haoxin CUI: conceptualization, investigation, methodology, formal analysis, writing-original draft, writing-review & editing. Naymul KARIM: methodology, writing-review & editing. Feng JIANG: methodology, investigation. Haimei HU: methodology, investigation. Wei CHEN: conceptualization, supervision, resources, funding acquisition, writing-review & editing. All authors have read and approved the final manuscript, and therefore, have full access to all the data in the study and take responsibility for the integrity and security of the data. 10.1631/jzus.B2200030 1673-1581（2022）07-0578-09 This work was supported by the Starry Night Science Fund of Zhejiang University Shanghai Institute for Advanced Study (No. SN-ZJU-SIAS-0013) and the National Key Technology R&D Program of China (No. 2016YFD0401201). 2022-01-16 2022-04-10 2022-07-15 2022-12-27 2022-06-02 Copyright © Zhejiang University and Springer-Verlag GmbH Germany, part of Springer Nature 2022 2022 浙江大学出版社 Haoxin CUI, Naymul KARIM, Feng JIANG, Haimei HU, and Wei CHEN declare that they have no conflict of interest. This article does not contain any studies with human or animal subjects performed by any of the authors. Compliance with ethics guidelines 浙江大学学报（英文版）（B辑：生物医学和生物技术） 7 23