一种水溶性免疫佐剂应用于小分子化合物单克隆抗体制备的效果评价

Evaluation of a water-soluble adjuvant for the development of monoclonal antibodies against small-molecule compounds 一种水溶性免疫佐剂应用于小分子化合物单克隆抗体制备的效果评价 first-author corresp ‡Corresponding Author ‡Corresponding Author †E-mail:yirongguo@zju.edu.cn †E-mail:yirongguo@zju.edu.cn yirongguo@zju.edu.cn Institute of Pesticide and Environmental Toxicology, Zhejiang University, Hangzhou 310058, China Institute of Pesticide and Environmental Toxicology, Zhejiang University, Hangzhou 310058, China A water-soluble adjuvant named QuickAntibody (QA) was introduced into the procedure of mouse immunization for the development of hapten-specific monoclonal antibodies (mAbs), using four kinds of pesticides as model compounds. Compared with conventional Freund’s adjuvants, QA treatments offered relatively low but acceptable antiserum titers after three inoculations, gave little adverse effects to the experimental animals, and were preferable in harvesting splenocytes during the steps of cell fusion. Afterwards, hybridomas from the QA group were prepared and screened by both non-competitive and competitive indirect enzyme-linked immunosorbent assays (ELISAs). The efficiency of gaining immune-positive hybridomas was satisfactory, and the resultant mAbs showed sensitivities (half maximal inhibitory concentration (IC 50 )) of 0.91, 2.46, 3.72, and 6.22 ng/ml to triazophos, parathion, chlorpyrifos, and fenpropathrin, respectively. Additionally, the performance of QA adjuvant was further confirmed by acquiring a high-affinity mAb against okadaic acid (IC 50 of 0.36 ng/ml) after three immunizations. These newly developed mAbs showed similar or even better sensitivities compared with previously reported mAbs specific to the corresponding analytes. This study suggested that the easy-to-use adjuvant could be applicable to the efficient generation of highly sensitive mAbs against small compounds. 目的 2 评价一种新型水溶性免疫佐剂在制备小分子化合物单克隆抗体（单抗）中的应用效果。 创新点 2 采用一种新型水溶性免疫佐剂，快速制备了分别针对4种农药和1种海洋毒素的高亲合力单抗，且其性能与以往采用弗氏佐剂获得的相应单抗非常接近。 方法 2 本研究以4种农药和1种海洋毒素为目标分析物，采用一种新型水溶性佐剂与小分子抗原相互 混合，直接对Balb/c小鼠进行小腿肌肉注射免疫。 经过2~3次免疫后进行腹腔注射常规末次免疫，细胞 融合后筛选出了相应的杂交瘤细胞株，制备并鉴定了针对上述半抗原小分子的特异性单抗。 结论 2 采用该水溶性免疫佐剂制备抗原注射溶液无需乳化过程，免疫操作简便，且对小鼠负面效应较小；虽然该处理小鼠产生的抗血清效价并没有像常规弗氏免疫佐剂带来的效价值高，但细胞融合后筛选得到有效细胞株的概率尚可；获得的针对目标分析物的单抗在灵敏度和特异性等方面都接近于以往采用弗氏佐剂获得的单抗。试验结果表明，该水溶性免疫佐剂适用于针对小分子化合物单抗的高效制备。 Water-soluble adjuvant Monoclonal antibody Hapten-specific antibody High affinity 水溶性免疫佐剂 单克隆抗体 半抗原特异性 高亲合力 Introduction 1 Naturally occurring antibodies, especially monoclonal antibodies (mAbs), have proved to be versatile biological tools in modern bioanalytical methods for the determination of both macromolecules and low-molecular-weight compounds (e.g. drugs of abuse, pesticides, mycotoxins, antibiotics, and other contaminants in environmental and food samples). By comparison, the development of high-affinity mAbs against small molecules (haptens) is relatively difficult and usually needs long preparation time (more than four immunizations), because haptens have no immunogenicity and must firstly be coupled to carrier proteins to sufficiently provoke an immune response. Additionally, compared with the chance to obtain high-affinity antibodies against large molecules (e.g. protein antigens), the chance to get the effective mAbs with free hapten-binding ability is relatively low. For instance, only three hybridomas of interest were found among a total of 8700 cultured wells from ten fusions in a previous report on the production of mAbs against oxytetracycline, an antibiotic with the molecular weight of 460.4 Da (Wongtangprasert et al., 2014 2014 ). Immunologic adjuvants are essential for immunization. In cases where the antigen is of weak immunogenicity or has a very limited availability, the type and role of adjuvant become key components for producing excellent antibodies (Stils, 2005 2005 ). For research purposes, Freund’s adjuvant (complete or incomplete) is still the most extensively used and effective for making the water-in-oil emulsion for immunization of laboratory animals. Unfortunately, the water-in-oil emulsion tends to denature protein antigens, thus hindering the induction of antibodies against specific epitopes (Algate et al., 2013 2013 ). Moreover, it is inherently toxic and may cause abscesses and granulomas at injection sites, resulting in high concern for research animals. Hence, many researchers and animal care facilities encourage the use of other adjuvants. Ideally, an adjuvant should support an immune response against a wide variety of antigen structures even if exhibiting little antigenicity. Up to now, some alternatives (e.g. TiterMax™, Ribi™, and Gerbu™ adjuvants) have been invented to generate a potent immune response with significantly reduced toxicity (Stils, 2005 2005 ; Algate et al., 2013 2013 ), but most of the evaluation studies were focused on developing antibodies to macromolecules. Only a few investigations have been carried out to find replacements for Freund’s adjuvants in the production of hapten-specific antibodies (Erhard et al., 1991 1991 ; Fodey et al., 2008 2008 ; George et al., 2012 2012 ; Maquieira et al., 2012 2012 ; Parra et al., 2013 2013 ). Recently, a novel proprietary adjuvant named QuickAntibody (QA), invented by Beijing Biodragon Immunotechnologies Co. in China, was designed specifically for eliciting monoclonal and polyclonal antibodies in mice. It is formulated with pathogen-associated molecular patterns containing several Toll-like receptor ligands and cationic polymers to activate cytosolic pathogen-recognition receptors, acting as an immune modulator. According to the manufacturer, QA is a ready-to-use water-compatible solution that can be easily mixed with any antigen before immunization through the simple operation of intra-muscular injection. Until now, it has mainly been used for the preparation of mouse antibodies against different types of bio-antigens (Ruan et al., 2013 2013 ; Zhang et al., 2013c 2013c ; Zhao M. et al., 2013 2013 ; He et al., 2014 2014 ; Zhao Z. et al., 2014 2014 ; Wang et al., 2015 2015 ), while the application of QA adjuvant in the preparation of mAbs against small-molecule compounds is limited to a few reports from one research group (Chen et al., 2013 2013 ; Zhang et al., 2013a 2013a ; 2013b 2013b ). Because the new water-soluble adjuvant was initially invented for macromolecular bio-antigens, to establish whether it is suitable for rapid development of mAbs towards various haptens requires many trials. The aim of this work was to evaluate QA as a potential candidate for the efficient generation of highly sensitive mAbs against small molecules. Several kinds of agricultural chemicals were taken as the target analytes. Additionally, mAbs for okadaic acid (OA), a marine biotoxin, were also developed by using the QA adjuvant, to explore its applicability. Materials and methods 1 Reagents and materials 2 Triazophos, parathion, chlorpyrifos, fenpropathrin, and other related pesticide standards were obtained from Agro-environmental Protection Institute, Ministry of Agriculture (Tianjin, China). OA standard was purchased from Algal Science Inc. (Taoyuan, Taiwan, China). Complete and incomplete Freund’s adjuvants, ovalbumin (OVA), bovine serum albumin (BSA), pristane, and rabbit anti-mouse IgG secondary antibody labeled with horseradish peroxidase (SecAb-HRP) were from Sigma-Aldrich (St. Louis, MO, USA). QA adjuvant was supplied by Kang Biquan Biotechnology (Beijing, China). O -phenylenediamine (OPD) and Tween 20 were purchased from Shanghai Chemical Reagents Company (China). Blue carrier protein (BCP) was purchased from Thermo Scientific (Rockford, USA). Ultra-pure water was acquired from a Milli-Q purification system (Millipore, Bedford, USA). Phosphate-buffered saline (PBS; 10 mmol/L, pH 7.4), carbonate-buffered saline (CBS; 50 mmol/L, pH 9.5), and OPD substrate solution (10 mg of OPD and 10 μl of 30% H 2 O 2 diluted with 25 ml of phosphate-citrate buffer at pH 5.4) were self-prepared. All other reagents were of analytical grade unless specified otherwise. MaxiSorp™ F96-well polystyrene microplates and different kinds of cell culture plates were obtained from Nalge Nunc International (Roskilde, Denmark). Protein concentrators (10 kDa molecular weight cutoff (MWCO), 20 ml) were purchased from Pall (New York, USA). Isotype classifications of the mAbs were performed by a commercially available kit from Thermo Scientific (Rockford, USA). The mouse SP2/0 myeloma cells were purchased from the Cell Bank at the Chinese Academy of Sciences (Shanghai, China). The functionalized derivatives (haptens) of target pesticides were designed and synthesized as described in our published research (Gui et al., 2006 2006 ; Jin et al., 2006 2006 ; Liu et al., 2007 2007 ; Liang et al., 2013 2013 ). Fig. 1 1 lists the chemical structures of related compounds used in the present work. Animals 2 Female Balb/c mice and F1 hybrid mice were provided by Shanghai Lab Animal Research Center (China). They were housed under standard conditions of temperature (20–25 °C) and humidity (40%–60%) with a 12-h light/dark cycle, and had free access to drinking water and a commercial pellet diet. Animal manipulations were carried out in compliance with Zhejiang University guidelines for the welfare of experimental animals. Preparation of hapten-protein conjugates 2 For pesticide immunogens, haptens were covalently attached to the lysine groups of BSA by the active ester method. To synthesize the hapten-OVA conjugates used as coating detective antigens, the mixed anhydride method was adopted using isobutyl chloroformate as the coupling reagent. Conjugates of OA-BCP and OA-BSA respectively serving as the immunogen and the coating antigen were prepared according to a previous research method (Lu et al., 2012 2012 ). Purification was performed by dialyzing extensively with PBS, followed by treatment with a protein concentrator. Immunization strategy 2 All hapten-protein immunogens in this study were administered at a dose of 50 μg per mouse for each inoculation, with the total injection volume of 100 μl. The injection solution was freshly prepared by simply mixing the immunogen in sterile saline with an equal volume of QA adjuvant, according to the QA product manual (the adjuvant should be shaken well before use, because some precipitation may appear after storage). For the initial immunization, three 6-week-old female Balb/c mice were given a single intramuscular injection. Three weeks later, the mice were boosted, and the third inoculation was given after another 14 d. One week later, mice were tail-bled and titers of antisera were tested by indirect enzyme-linked immunosorbent assays (ELISAs) to evaluate the immune responses. The most representative mouse that produced antibodies with both satisfying titer and the best recognition toward the test substance was selected for cell fusion. As control, the immune responses of mice immunized with conventional Freund’s adjuvants were also evaluated. Mice were administered with the similar immunization strategy and the same dose of immunogens as mentioned above. Primary immunization was carried out by multi-site subcutaneous injection using complete Freund’s adjuvant for emulsification, while subsequent boosters were administered by intraperitoneal injection using incomplete Freund’s adjuvant. Cell fusion and hybridoma screening 2 After a resting period of two weeks from the last injection with adjuvant, the mouse chosen to be the spleen donor received a final intraperitoneal booster with 50 μg of the immunogen dissolved in sterile saline (without adjuvant). Three days later, the spleen cells were collected and fused with SP2/0 myeloma cells. Fusion procedures were carried out essentially based on standard procedures and some details previously described (Wang et al., 2009 2009 ). Around 12‒14 d after cell fusion, non-competitive indirect ELISAs were used for primary screening of hybridomas. Wells showing the absorbance values higher than 0.5 were selected and filled with fresh medium. The next day, they were rechecked by competitive indirect ELISAs to test the ability to recognize the target compounds. Wells of hybridomas giving strong inhibition (more than 50%) by the analytes at 1 μg/ml and maintaining absorption values were expanded into 24-well culture plates. The supernatants were re-screened by ELISAs. Only those clones that still maintained high absorbance values, had strong affinity to the analytes, and displayed no cross-reactivity to OVA, were chosen for next-step selection (Zhang et al., 2009 2009 ). Normally, the top three hybridomas for each analyte were subjected to subcloning for 4‒6 cycles to get the final stable single-cell lines. For large-scale production of mAbs, the representative clone for each pesticide was intraperitoneally inoculated into F1 hybrid mice (106 cells per mouse), which were pre-treated with pristane (0.5 ml per mouse). After 7‒10 d, the ascites fluid was collected and then purified by caprylic acid-ammonium sulfate precipitation. Indirect ELISA 2 All incubations were conducted at 37 °C, except for the coating step. After each incubation, plates were washed three times with PBST (0.05% Tween 20 in PBS, 300 μl/well) using a 96-channel washer (Highcreation, Shenzhen, China). High-binding polystyrene microplates were filled with coating antigens diluted in CBS (100 μl/well) for incubation at 4 °C overnight. The next day, the plates were blocked with 2% (0.02 g/ml) skim milk in PBS (300 μl/well) for 30 min. For the competitive indirect ELISA, standard solutions of analytes were freshly prepared by PBS containing a certain percentage (v/v) of methanol as co-solvent, that is, 5% for triazophos, 10% for parathion, 20% for chlorpyrifos, and 30% for fenpropathrin, based on our previous work experience. Then, both blank control and analyte solutions were respectively added (50 μl/well), followed by adding 50 μl/well of antibodies diluted in PBS. After shaking and incubation for 1 h, 100 μl/well of SecAb-HRP (1:40 000 (v/v) dilution in PBS) was added and incubated for 45 min. Then, 100 μl/well of freshly prepared OPD substrate solution was added. The reaction was stopped after 15 min with 2 mol/L sulphuric acid (50 μl/well). Finally, the absorbance (optical density at 490 nm, OD 490 ) was measured by a SpectraMax i3 microplate reader (Molecular Devices, Sunnyvale, USA). Assay sensitivity test 2 Checkerboard titration was performed by competitive indirect ELISAs with a range of antibody and coating antigen dilutions. The combination of antibody and antigen dilutions which provided the greatest inhibition by adding the free analyte was ascertained to be optimal for subsequent use in the assay. Competitive standard curves were obtained by plotting the inhibition rate against the logarithm of analyte concentration. Simulation of standard curves was performed by means of Origin 8.5 software. The IC 50 value (i.e., analyte concentration that caused a 50% reduction of binding between the antibody and the coating antigen) was determined to estimate the assay sensitivity. Cross-reactivity study 2 To evaluate antibody specificity or assay selectivity, analogs of target pesticides were utilized to implement cross-reactivity studies. The IC 50 of each chemical was determined from its standard curve. Cross-reactivity (CR) values were calculated based on the following equation: CR=IC 50 (target analyte)/IC 50 (analogue)×100%. Results and discussion 2 Immunological response 2 The current study was undertaken to assess the efficacy of QA adjuvant for the rapid development of hapten-specific mAbs with high affinity, which could be applied to various detection methods for diverse chemical contaminants in the fields of food safety control and environmental monitoring. The primary indicator for evaluation was if QA could help to elicit a similar or enhanced immune response in the host animal without the adverse effects derived from Freund’s adjuvants. In the present work, the functionalized haptens for target pesticides were rationally designed according to our previous research results. Chemicals named THHe, PA0204, CHBu, and NC-S-2 were used as the immunizing haptens for triazophos (Gui et al., 2006 2006 ), parathion (Wang et al., 2009 2009 ), chlorpyrifos (Jin et al., 2006 2006 ), and α-cyano pyrethroids (Liang et al., 2013 2013 ), respectively. Moreover, a certain degree of hapten heterology is often employed to improve the detectability of competitive immunoassays for small-molecule analytes (Kim et al., 2003 2003 ; Wang et al., 2011 2011 ; Esteve-Turrillas et al., 2014 2014 ). Herein, based on our experience, moderately heterologous haptens (THBu, PA0304, CHHe, and NC-S-7) were used to choose the optimal competitor/antibody combinations for the establishment of highly sensitive immunoassays and maybe also for hybridoma screening. For primary testing of antiserum titers, homologous antigens were coated at 10 μg/ml for non-competitive indirect ELISAs and the antiserum dilutions offering OD 490 close to 1.0 were set as the titers. Fig. 2 2 presents their mean values from three mice in each group after the third immunization. It was clear that, for each pesticide treatment, the QA group generally showed relatively lower titer than the Freund’s group, but it was still acceptable. Apart from the titer measurement, the inhibition rate by the free analyte was further determined to see if useful antibody was produced, by adding a high concentration of the related pesticide in competitive indirect ELISAs. Because the antisera collected from mouse tails were very limited and our final purpose was to develop mAbs for these pesticides, working conditions of coating antigens and mouse antisera for ELISAs were not optimized, but just based on the fixed concentration of antigens at 10 μg/ml and the corresponding antiserum titers. According to the inhibition results caused by related pesticides (Table 1 1 ), there were no significant differences between the two adjuvant groups in all cases (Student’s t -test, P > 0.05), which seemed promising for gaining effective mAbs under the administration of QA adjuvant. Overall, the performance of QA was comparable to that of traditional Freund’s adjuvants based on the polyclonal antibody characteristics, although not as good as the manufacturer had announced (higher antibody titer and affinity). In competitive indirect ELISAs, 1 μg/ml of triazophos or parathion and 2 μg/ml of chlorpyrifos or fenpropathrin were individually used for inhibition measurement. The inhibition rate is the average value±standard deviation (SD) from three mice in each group Immunogen Adjuvant Coating antigen Inhibition rate (%) 4 THHe-BSA QA THHe-OVA 58.7±8.2 THBu-OVA 79.4±9.1 Freund’s THHe-OVA 61.2±6.7 THBu-OVA 85.5±8.7 4 PA0204-BSA QA PA0204-OVA 54.3±6.5 PA0304-OVA 67.7±9.3 Freund’s PA0204-OVA 49.0±7.1 PA0304-OVA 71.1±7.6 4 CHBu-BSA QA CHBu-OVA 36.2±4.8 CHHe-OVA 43.0±4.0 Freund’s CHBu-OVA 38.6±5.5 CHHe-OVA 43.3±7.0 4 NC-S-2-BSA QA NC-S-2-OVA 15.7±5.4 NC-S-7-OVA − Freund’s NC-S-2-OVA 18.6±5.9 NC-S-7-OVA − Additionally, heterologous coating antigens were also implemented for comparison. As for triazophos and parathion, using THBu-OVA and PA0304-OVA as the competitors indeed promoted the assay sensitivities for the target pesticides in the cases of both adjuvants, whereas the heterologous ELISA gave no substantial improvement in the case of chlorpyrifos. For the NC-S-2-BSA group, it was found that the resultant antiserum could only well recognize the homologous antigen, and the most notable inhibition was induced by fenpropathrin among several α-cyano pyrethroids such as deltamethrin, cypermethrin, cyhalothrin, and fenvalerate. This result contradicted our initial expectation, since the preceding rabbit polyclonal antibodies generated from NC-S-2-BSA could recognize the heterologous coating antigen NC-S-7-OVA, and the established ELISA displayed a close affinity to a few α-cyano pyrethroids (Liang et al., 2013 2013 ). It must be associated with the fact that antibodies produced from different animals can have different recognition spectra (specificity). Based on these antiserum results, except for NC-S-2-BSA hybridomas, indirect ELISAs coated with heterologous antigens could be used for hybridoma screening, in order to reduce the proportion of false positives caused by the spacer arms or the whole hapten-arm regions (Guo et al., 2014 2014 ). Animal health 2 When samples of tail blood were collected, mouse reactions to the immunogens were evaluated by monitoring the injection sites for the presence of adverse effects such as inflammation, abscess, or granuloma. Through the whole period of trials, none of the mice administered with QA was found to have severe adverse reactions in all pesticide groups, except that two mice appeared to have a little swelling at the intra-muscular injection sites. In contrast, granulomas were observed at almost all subcutaneous sites of each mouse injected with Freund’s adjuvant. Fortunately, each mouse remained active until the study was completed. Therefore, QA seemed to be a relatively safe adjuvant with negligible side-effects in mice. It may have the potential to be applied in making vaccines for drugs of abuse and addiction. The theoretical basis of such vaccines is to induce antibodies that capture the drugs in the blood and thus are not able to cross the blood-brain barrier, thereby preventing psychoactive effects (Alving et al., 2014 2014 ). Since injection of T cell-independent haptenic drugs hardly triggers memory recall responses, a potent and safe adjuvant for vaccine immunization plays a critical role (Alving et al., 2014 2014 ). Cell fusion and hybridoma selection 2 The objective of this study was to assess the performance of QA on the production of highly sensitive mouse mAbs toward small molecules, in that the adjuvant manufacturer did not conduct these trials before commercialization. Thus, apart from antiserum titer and affinity, the efficiency of generating hapten-specific hybridoma clones also should be examined and taken into account. Since cell fusion per se is a technically crucial part of this study, all the fusion procedures were manipulated by one person to minimize individual differences. After antiserum screening, the most representative mouse from each group was selected and sacrificed for cell fusion. It is normal that, in cases of Freund’s mice, it takes a few minutes to get rid of some white adipose tissues surrounding the spleens before the harvest of splenocytes. In fact, the spleens looked very clean and were more easily isolated from QA mice. This fact might be related to the intramuscular injections for QA treatment, which were different from the intraperitoneal injections for Freund’s mice. This could be another advantage of QA over Freund’s adjuvants in the aspect of easy handling for splenocyte harvesting. Due to a large number of spleen cells, at least ten 96-well plates were used to distribute the fused cell suspension. The fusion rates were satisfactory, since more than 80% of wells contained at least one cluster of hybridomas. After checking by both non-competitive and competitive ELISAs (antigens coated at 10 μg/ml), only wells of hybridomas with satisfying affinity to analytes were selected for expansion, so as to decrease unnecessary workload and exorbitant use of precious materials in the following steps. We realized that using a high concentration at 10 μg/ml for the coating antigen would not favor the competition, and hence some clones with a certain affinity to the free pesticides would be neglected. However, from another point of view, only clones with high affinity to the target analytes could be quickly selected as the useful hybridomas, reducing the number of clones with fairly low affinity. Table 2 2 shows the hybridoma screening results from mice administered with QA adjuvant. For each pesticide, more than 20 wells were found to be strongly positive (OD 490 ≥0.5). Among them, at least 30% of wells displayed great inhibition (more than 50% by 1 μg/ml of analyte). This was unexpected, but interesting, although the antiserum titer of QA group was not as high as that of Freund’s group. The finding was consistent with a systematically comparative study of seven adjuvants, reporting that there was no correlation between the polyclonal antibody titer and the frequency of immune-positive clones (Ferber et al., 1999 1999 ). Furthermore, on many occasions of producing antibodies against haptens, it does not follow that higher titer indicates greater sensitivity to the free analyte (Fodey et al., 2008 2008 ; George et al., 2012 2012 ). Overall, the QA adjuvant could be used to generate hapten-specific hybridoma clones with a satisfactorily efficient rate. Inhibition by 1 μg/ml of target pesticide Pesticide Immunogen Wells of OD 490 ≥0.5 Wells of inhibition ≥50% a a Efficient rate (%)  Triazophos THHe-BSA 24 19 79.2  Parathion PA0204-BSA 95 30 31.6  Chlorpyrifos CHBu-BSA 85 28 32.9  Fenpropathrin NC-S-2-BSA 27 8 29.6 Antibody characterization 2 After subcloning and re-checking, the most sensitive and steady hybridoma clone representative for each pesticide was injected into F1 hybrid mice for ascites production. Isotypes of the purified mAbs were mostly IgG1 heavy chain and kappa light chain (Table 3 3 ). The mAbs for comparison were derived from immunizing haptens with the same or very similar structures, and sensitivities were tested by competitive indirect ELISAs 2 Pesticide 2 Clone name 2 Isotype 2 IC 50 (ng/ml) This work Literature a a  Triazophos THHe-QA2-8C10 IgG1, lambda 0.91 2.54 (Jin et al., 2008 2008 )  Parathion PA0204-QA1-7C2 IgG1, kappa 2.46 2.94 (Wang et al., 2009 2009 ); 7.06 (Li et al., 2015 2015 )  Chlorpyrifos CHBu-QA2-13C7 IgG1, kappa 3.72 24 (Kim et al., 2011 2011 ); 3.5 (around 10 nmol/L) (Manclús et al., 1996 1996 )  Fenpropathrin NC-S-2-QA2-1C3 IgG2a, kappa 6.22 14.03 (Chen et al., 2014 2014 ) Under suitable working concentrations of immunoreagents, the sensitivities of mAbs were measured by indirect competitive ELISAs with both homologous and heterologous coating antigens. As shown in Fig. 3 3 , antibody sensitivities were significantly enhanced in heterologous formats for all three organophosphorus pesticides. For chlorpyrifos, improvement of one order of magnitude was observed, with IC 50 value decreasing from 25.15 ng/ml (CHBu-OVA-based ELISA) to 3.72 ng/ml (CHHe-OVA-based ELISA). Table 3 3 summarizes the mAbs’ sensitivities (IC 50 ) to the four pesticides in this study and in previous work, based on competitive indirect ELISAs. It was pleasing to find that the newly developed mAbs induced by the QA system could provide similar or even better sensitivities to the target analytes, compared with results from other publications (Manclús et al., 1996 1996 ; Jin et al., 2008 2008 ; Wang et al., 2009 2009 ; Kim et al., 2011 2011 ; Chen et al., 2014 2014 ; Li et al., 2015 2015 ), in which Freund’s adjuvants and the traditional immunization strategy were used (mostly with the dose of 100 μg per mouse for each inoculation and 4–5 immunizations at 2-or 3-week intervals). These results were probably ascribed to features of the QA adjuvant, such as being water-compatible and with little influence of natural antigen conformation. Therefore, the new water-soluble adjuvant proved to be suitable for the efficient production of high-affinity mAbs against small chemicals. Data are expressed as mean±SD, with n =6 The specificity of the mAbs was measured by cross-reactions with related pesticide analogues. As seen from Fig. 4 4 , these new mAbs were generally specific to the target analytes, except that mAbs for parathion and chlorpyrifos had around 20%–25% cross-reactivity to methyl-parathion and methyl-chlorpyrifos, respectively. As shown in Fig. 5 5 , mAb for fenpropathrin exhibited around 4%–15% cross-reactivity to cypermethrin, deltamethrin, and cyhalothrin. These minor cross-reactions seemed difficult to avoid on the basis of their similar structures, which were also observed in previous work (Wang et al., 2009 2009 ; Liu et al., 2011 2011 ; Chen et al., 2014 2014 ). Certainly, cross-reactivity data herein may vary somewhat from values obtained in future applications, because of different assay formats, reaction systems, and so on. Development of mouse antibody for okadaic acid 2 Since OA is a kind of marine biotoxin and its standard is expensive, the dosage for effective immunization is usually chosen to be as small as possible. Having achieved satisfactory performance in pesticide trials, we directly used QA adjuvant for OA-BCP injection to check if it could also help provoke high-affinity antibodies toward OA with fewer inoculations over a relatively short duration. One week after the first booster injection (Day 28), mouse antisera were collected and characterized by non-competitive indirect ELISAs coated with OA-BSA at the concentration of 5 μg/ml. The titers ranged from 1/4000 to 1/16 000 for three OA-BCP mice, suggesting pretty quick and good immune responses. After cell fusion and hybridoma selection, a most sensitive and stable clone named OA-QA1-1H10 was finally acquired, which secreted mAb against OA with IC 50 of 0.36 ng/ml (Fig. 6 6 ). The sensitivity profile was much better than those of some similarly reported mAbs, which were produced from traditional Freund’s (IC 50 4.40 ng/ml (Lu et al., 2012 2012 )) and other kinds of adjuvants (IC 50 4.80 ng/ml (Stewart et al., 2009 2009 )). Also, it was very close to that from the recent work showing IC 50 of 0.58 ng/ml based on the competitive indirect ELISA (Liu et al., 2014 2014 ), where Freund’s complete adjuvant was used only once for the primary inoculation during the whole immunization period. Additionally, in the three previous studies, it took 4–6 inoculations and the total immunogen dose of 240–300 μg per mouse. Data are expressed as mean±SD, with n =6 The present results demonstrate that QA adjuvant could promote strong immune responses for OA within two immunizations (over less than one month). It seemed to be relatively time-saving, labor-saving, and cost-effective, and particularly may be suitable for the efficient development of antibodies against expensive and toxic chemicals like biotoxins. Even so, we still expended a total 150 μg of immunogen per mouse in this work. Thus, a lower dosage for immunization should be applied in future studies, in view of the biotoxicity of marine toxins and their high costs. Nonetheless, undoubtedly, there is no single adjuvant that is right for all situations. The study of the application of QA to other types of antigens is on-going. Conclusions 2 An easy-to-use QA adjuvant was employed and investigated for producing mAbs toward different kinds of low-molecular-weight compounds. Results indicated that under the recommended immunization strategy, the antiserum titers elicited from QA adjuvant were relatively lower than those from Freund’s adjuvants with the same dose of immunogen, while the fusion efficiency for immune-positive clones was still satisfactory in the administration of QA. As a result, five kinds of newly developed mAbs were obtained with high sensitivities to the corresponding target analytes, which can be applied to the trace-analysis of these contaminants in food and environmental samples. Additionally, by using QA adjuvant, it only required 2–3 immunizations before cell fusion, which fairly shortens the conventional immunization period for generating hapten-specific mAbs. Therefore, the new water-soluble adjuvant could be used for rapidly producing effective mAbs against small-molecule contaminants, although only part of its advantages as claimed by the manufacturer was confirmed in the current work. Further comparison studies with other adjuvants should be carried out. References P Algate , J Baldridge , SP Mossman . GC Howard , MR Kaser . Antigens and adjuvants . Making and Using Antibodies: A Practical Handbook , 2013 . : London CRC Press , 22 - 30 . . Antigens and adjuvants CR Alving , GR Matyas , O Torres , 等 . Adjuvants for vaccines to drugs of abuse and addiction . Vaccine , 2014 . 32 ( 42 ): 5382 - 5389 . (Available from: http://dx.doi.org/10.1016/j.vaccine.2014.07.085 http://dx.doi.org/10.1016/j.vaccine.2014.07.085 ) . Adjuvants for vaccines to drugs of abuse and addiction X Chen , L Liu , H Kuang , 等 . A strip-based immunoassay for rapid determination of fenpropathrin . Anal Methods , 2013 . 5 ( 21 ): 6234 - 6239 . (Available from: http://dx.doi.org/10.1039/C3AY41030G http://dx.doi.org/10.1039/C3AY41030G ) . A strip-based immunoassay for rapid determination of fenpropathrin X Chen , L Xu , W Ma , 等 . General immunoassay for pyrethroids based on a monoclonal antibody . Food Agric Immunol , 2014 . 25 ( 3 ): 341 - 349 . (Available from: http://dx.doi.org/10.1080/09540105.2013.794328 http://dx.doi.org/10.1080/09540105.2013.794328 ) . General immunoassay for pyrethroids based on a monoclonal antibody M Erhard , J Kellner , R Kühlmann , 等 . Influence of various adjuvants on the synthesis of specific antibodies of chicken, sheep and rabbit following immunization with an hapten . J Vet Med A , 1991 . 38 ( 1-10 ): 21 - 27 . (Available from: http://dx.doi.org/10.1111/j.1439-0442.1991.tb00979.x http://dx.doi.org/10.1111/j.1439-0442.1991.tb00979.x ) . Influence of various adjuvants on the synthesis of specific antibodies of chicken, sheep and rabbit following immunization with an hapten FA Esteve-Turrillas , JV Mercader , C Agullo , 等 . Design and development of heterologous competitive immunoassays for the determination of boscalid residues . Analyst , 2014 . 139 ( 14 ): 3636 - 3644 . (Available from: http://dx.doi.org/10.1039/C3AN01104F http://dx.doi.org/10.1039/C3AN01104F ) . Design and development of heterologous competitive immunoassays for the determination of boscalid residues PC Ferber , P Ossent , FR Homberger , 等 . The generation of monoclonal antibodies in mice: influence of adjuvants on the immune response, fusion efficiency and distress . Lab Anim , 1999 . 33 ( 4 ): 334 - 350 . (Available from: http://dx.doi.org/10.1258/002367799780487896 http://dx.doi.org/10.1258/002367799780487896 ) . The generation of monoclonal antibodies in mice: influence of adjuvants on the immune response, fusion efficiency and distress TL Fodey , P Delahaut , C Charlier , 等 . Comparison of three adjuvants used to produce polyclonal antibodies to veterinary drugs . Vet Immunol Immunopathol , 2008 . 122 ( 1-2 ): 25 - 34 . (Available from: http://dx.doi.org/10.1016/j.vetimm.2007.10.016 http://dx.doi.org/10.1016/j.vetimm.2007.10.016 ) . Comparison of three adjuvants used to produce polyclonal antibodies to veterinary drugs SE George , CT Elliott , DP McLaughlin , 等 . An investigation into the potential use of nanoparticles as adjuvants for the production of polyclonal antibodies to low molecular weight compounds . Vet Immunol Immunopathol , 2012 . 149 ( 1-2 ): 46 - 53 . (Available from: http://dx.doi.org/10.1016/j.vetimm.2012.06.002 http://dx.doi.org/10.1016/j.vetimm.2012.06.002 ) . An investigation into the potential use of nanoparticles as adjuvants for the production of polyclonal antibodies to low molecular weight compounds WJ Gui , RY Jin , ZL Chen , 等 . Hapten synthesis for enzyme-linked immunoassay of the insecticide triazophos . Anal Biochem , 2006 . 357 ( 1 ): 9 - 14 . (Available from: http://dx.doi.org/10.1016/j.ab.2006.07.023 http://dx.doi.org/10.1016/j.ab.2006.07.023 ) . Hapten synthesis for enzyme-linked immunoassay of the insecticide triazophos Y Guo , M Sanders , A Galvita , 等 . Heterologous screening of hybridomas for the development of broad-specific monoclonal antibodies against deoxynivalenol and its analogues . World Mycotoxin J , 2014 . 7 ( 3 ): 257 - 265 . (Available from: http://dx.doi.org/10.3920/WMJ2013.1668 http://dx.doi.org/10.3920/WMJ2013.1668 ) . Heterologous screening of hybridomas for the development of broad-specific monoclonal antibodies against deoxynivalenol and its analogues Y He , W Ma , Y Li , 等 . Expression of metallothionein of freshwater crab ( Sinopotamon henanense ) in Escherichia coli enhances tolerance and accumulation of zinc, copper and cadmium . Ecotoxicology , 2014 . 23 ( 1 ): 56 - 64 . (Available from: http://dx.doi.org/10.1007/s10646-013-1151-0 http://dx.doi.org/10.1007/s10646-013-1151-0 ) . Expression of metallothionein of freshwater crab (Sinopotamon henanense) in Escherichia coli enhances tolerance and accumulation of zinc, copper and cadmium RY Jin , WJ Gui , JX Wu , 等 . Study on the monoclonal antibody to chlorpyrifos . J Zhejiang Univ (Agric Life Sci) , 2006 . 32 ( 2 ): 591 - 597 . (in Chinese) . Study on the monoclonal antibody to chlorpyrifos RY Jin , WJ Gui , YR Guo , 等 . Comparison of monoclonal antibody-based ELISA for triazophos between the indirect and direct formats . Food Agric Immunol , 2008 . 19 ( 1 ): 49 - 60 . (Available from: http://dx.doi.org/10.1080/09540100801933454 http://dx.doi.org/10.1080/09540100801933454 ) . Comparison of monoclonal antibody-based ELISA for triazophos between the indirect and direct formats YA Kim , EH Lee , KO Kim , 等 . Competitive immunochromatographic assay for the detection of the organophosphorus pesticide chlorpyrifos . Anal Chim Acta , 2011 . 693 ( 1-2 ): 106 - 113 . (Available from: http://dx.doi.org/10.1016/j.aca.2011.03.011 http://dx.doi.org/10.1016/j.aca.2011.03.011 ) . Competitive immunochromatographic assay for the detection of the organophosphorus pesticide chlorpyrifos YJ Kim , YA Cho , H Lee , 等 . Investigation of the effect of hapten heterology on immunoassay sensitivity and development of an enzyme-linked immunosorbent assay for the organophosphorus insecticide fenthion . Anal Chim Acta , 2003 . 494 ( 1-2 ): 29 - 40 . (Available from: http://dx.doi.org/10.1016/j.aca.2003.07.003 http://dx.doi.org/10.1016/j.aca.2003.07.003 ) . Investigation of the effect of hapten heterology on immunoassay sensitivity and development of an enzyme-linked immunosorbent assay for the organophosphorus insecticide fenthion X Li , H Zhang , Y Ji , 等 . Immunochemical and molecular characteristics of monoclonal antibodies against organophosphorus pesticides and effect of hapten structures on immunoassay selectivity . Food Agric Immunol , 2015 . 26 ( 1 ): 109 - 119 . (Available from: http://dx.doi.org/10.1080/09540105.2013.873390 http://dx.doi.org/10.1080/09540105.2013.873390 ) . Immunochemical and molecular characteristics of monoclonal antibodies against organophosphorus pesticides and effect of hapten structures on immunoassay selectivity X Liang , R Xie , C Wang , 等 . Development of a broad-selective immunoassay for multi-residue determination of type II pyrethroids in West Lake water . Food Agric Immunol , 2013 . 24 ( 1 ): 59 - 78 . (Available from: http://dx.doi.org/10.1080/09540105.2011.641169 http://dx.doi.org/10.1080/09540105.2011.641169 ) . Development of a broad-selective immunoassay for multi-residue determination of type II pyrethroids in West Lake water BH Liu , CT Hung , CC Lu , 等 . Production of monoclonal antibody for okadaic acid and its utilization in an ultrasensitive enzyme-linked immunosorbent assay and one-step immunochromatographic strip . J Agric Food Chem , 2014 . 62 ( 6 ): 1254 - 1260 . (Available from: http://dx.doi.org/10.1021/jf404827s http://dx.doi.org/10.1021/jf404827s ) . Production of monoclonal antibody for okadaic acid and its utilization in an ultrasensitive enzyme-linked immunosorbent assay and one-step immunochromatographic strip YH Liu , MJ Jin , WJ Gui , 等 . Hapten design and indirect competitive immunoassay for parathion determination: correlation with molecular modeling and principal component analysis . Anal Chim Acta , 2007 . 591 ( 2 ): 173 - 182 . (Available from: http://dx.doi.org/10.1016/j.aca.2007.03.071 http://dx.doi.org/10.1016/j.aca.2007.03.071 ) . Hapten design and indirect competitive immunoassay for parathion determination: correlation with molecular modeling and principal component analysis YH Liu , J Chen , YR Guo , 等 . A sensitive monoclonal antibody-based enzyme-linked immunosorbent assay for chlorpyrifos residue determination in Chinese agricultural samples . J Environ Sci Health B , 2011 . 46 ( 4 ): 313 - 320 . (Available from: http://dx.doi.org/10.1080/03601234.2011.559884 http://dx.doi.org/10.1080/03601234.2011.559884 ) . A sensitive monoclonal antibody-based enzyme-linked immunosorbent assay for chlorpyrifos residue determination in Chinese agricultural samples S Lu , Y Zhou , Y Li , 等 . Production of monoclonal antibody and application in indirect competitive ELISA for detecting okadaic acid and dinophytoxin-1 in seafood . Environ Sci Pollut Res Int , 2012 . 19 ( 7 ): 2619 - 2626 . (Available from: http://dx.doi.org/10.1007/s11356-012-0819-y http://dx.doi.org/10.1007/s11356-012-0819-y ) . Production of monoclonal antibody and application in indirect competitive ELISA for detecting okadaic acid and dinophytoxin-1 in seafood JJ Manclús , J Primo , A Montoya . Development of enzyme-linked immunosorbent assays for the insecticide chlorpyrifos. 1. Monoclonal antibody production and immunoassay design . J Agric Food Chem , 1996 . 44 ( 12 ): 4052 - 4062 . (Available from: http://dx.doi.org/10.1021/jf960144q http://dx.doi.org/10.1021/jf960144q ) . Development of enzyme-linked immunosorbent assays for the insecticide chlorpyrifos. 1. Monoclonal antibody production and immunoassay design Á Maquieira , EM Brun , M Garcés-García , 等 . Aluminum oxide nanoparticles as carriers and adjuvants for eliciting antibodies from non-immunogenic haptens . Anal Chem , 2012 . 84 ( 21 ): 9340 - 9348 . (Available from: http://dx.doi.org/10.1021/ac3020998 http://dx.doi.org/10.1021/ac3020998 ) . Aluminum oxide nanoparticles as carriers and adjuvants for eliciting antibodies from non-immunogenic haptens J Parra , A Abad-Somovilla , JV Mercader , 等 . Carbon nanotube-protein carriers enhance size-dependent self-adjuvant antibody response to haptens . J Control Release , 2013 . 170 ( 2 ): 242 - 251 . (Available from: http://dx.doi.org/10.1016/j.jconrel.2013.05.019 http://dx.doi.org/10.1016/j.jconrel.2013.05.019 ) . Carbon nanotube-protein carriers enhance size-dependent self-adjuvant antibody response to haptens X Ruan , S Huang , L Shao , 等 . Monoclonal antibodies against NS4B protein of Japanese encephalitis virus . Monoclon Antib Immunodiagn Immunother , 2013 . 32 ( 6 ): 382 - 385 . (Available from: http://dx.doi.org/10.1089/mab.2013.0041 http://dx.doi.org/10.1089/mab.2013.0041 ) . Monoclonal antibodies against NS4B protein of Japanese encephalitis virus LD Stewart , CT Elliott , AD Walker , 等 . Development of a monoclonal antibody binding okadaic acid and dinophysistoxins-1, -2 in proportion to their toxicity equivalence factors . Toxicon , 2009 . 54 ( 4 ): 491 - 498 . (Available from: http://dx.doi.org/10.1016/j.toxicon.2009.05.015 http://dx.doi.org/10.1016/j.toxicon.2009.05.015 ) . Development of a monoclonal antibody binding okadaic acid and dinophysistoxins-1, -2 in proportion to their toxicity equivalence factors HF Stils . Adjuvants and antibody production: dispelling the myths associated with Freund’s complete and other adjuvants . ILAR J , 2005 . 46 ( 3 ): 280 - 293 . (Available from: http://dx.doi.org/10.1093/ilar.46.3.280 http://dx.doi.org/10.1093/ilar.46.3.280 ) . Adjuvants and antibody production: dispelling the myths associated with Freund’s complete and other adjuvants C Wang , Y Liu , Y Guo , 等 . Development of a McAb-based immunoassay for parathion and influence of the competitor structure . Food Chem , 2009 . 115 ( 1 ): 365 - 370 . (Available from: http://dx.doi.org/10.1016/j.foodchem.2008.11.091 http://dx.doi.org/10.1016/j.foodchem.2008.11.091 ) . Development of a McAb-based immunoassay for parathion and influence of the competitor structure M Wang , L Wang , Y Guo , 等 . The broad pattern recognition spectrum of the Toll-like receptor in mollusk Zhikong scallop Chlamys farreri . Dev Comp Immunol , 2015 . 52 ( 2 ): 192 - 201 . (Available from: http://dx.doi.org/10.1016/j.dci.2015.05.011 http://dx.doi.org/10.1016/j.dci.2015.05.011 ) . The broad pattern recognition spectrum of the Toll-like receptor in mollusk Zhikong scallop Chlamys farreri Z Wang , J Zhang , S Zhang , 等 . Heterologous structure of coating antigen on sensitivity of ELISA for sulfamethazine: evidence from molecular similarity analysis . Food Agric Immunol , 2011 . 22 ( 2 ): 115 - 124 . (Available from: http://dx.doi.org/10.1080/09540105.2010.533752 http://dx.doi.org/10.1080/09540105.2010.533752 ) . Heterologous structure of coating antigen on sensitivity of ELISA for sulfamethazine: evidence from molecular similarity analysis T Wongtangprasert , W Natakuathung , U Pimpitak , 等 . Production of a monoclonal antibody against oxytetracycline and its application for oxytetracycline residue detection in shrimp . J Zhejiang Univ-Sci B (Biomed & Biotechnol) , 2014 . 15 ( 2 ): 165 - 172 . (Available from: http://dx.doi.org/10.1631/jzus.B1300181 http://dx.doi.org/10.1631/jzus.B1300181 ) . Production of a monoclonal antibody against oxytetracycline and its application for oxytetracycline residue detection in shrimp D Zhang , P Li , Q Zhang , 等 . Production of ultrasensitive generic monoclonal antibodies against major aflatoxins using a modified two-step screening procedure . Anal Chim Acta , 2009 . 636 ( 1 ): 63 - 69 . (Available from: http://dx.doi.org/10.1016/j.aca.2009.01.010 http://dx.doi.org/10.1016/j.aca.2009.01.010 ) . Production of ultrasensitive generic monoclonal antibodies against major aflatoxins using a modified two-step screening procedure X Zhang , M Feng , L Liu , 等 . Detection of aflatoxins in tea samples based on a class-specific monoclonal antibody . Int J Food Sci Technol , 2013 . 48 ( 6 ): 1269 - 1274 . (Available from: http://dx.doi.org/10.1111/ijfs.12086 http://dx.doi.org/10.1111/ijfs.12086 ) . Detection of aflatoxins in tea samples based on a class-specific monoclonal antibody X Zhang , L Liu , X Chen , 等 . Immunochromatographic strip development for ultrasensitive analysis of aflatoxin M1 . Anal Methods , 2013 . 5 ( 23 ): 6567 - 6571 . (Available from: http://dx.doi.org/10.1039/C3AY41498A http://dx.doi.org/10.1039/C3AY41498A ) . Immunochromatographic strip development for ultrasensitive analysis of aflatoxin M1 X Zhang , Y Zhang , J Liu , 等 . PotD protein stimulates biofilm formation by Escherichia coli . Biotechnol Lett , 2013 . 35 ( 7 ): 1099 - 1106 . (Available from: http://dx.doi.org/10.1007/s10529-013-1184-8 http://dx.doi.org/10.1007/s10529-013-1184-8 ) . PotD protein stimulates biofilm formation by Escherichia coli M Zhao , Y Bai , W Liu , 等 . Immunization of N terminus of enterovirus 71 VP4 elicits cross-protective antibody responses . BMC Microbiol , 2013 . 13 ( 1 ): 287 (Available from: http://dx.doi.org/10.1186/1471-2180-13-287 http://dx.doi.org/10.1186/1471-2180-13-287 ) . Immunization of N terminus of enterovirus 71 VP4 elicits cross-protective antibody responses Z Zhao , B Li , H Sun , 等 . Fine-mapping of immunodominant linear B-cell epitopes of the Staphylococcus aureus SEB antigen using short overlapping peptides . PLoS ONE , 2014 . 9 ( 3 ): e90445 (Available from: http://dx.doi.org/10.1371/journal.pone.0090445 http://dx.doi.org/10.1371/journal.pone.0090445 ) . Fine-mapping of immunodominant linear B-cell epitopes of the Staphylococcus aureus SEB antigen using short overlapping peptides Compliance with ethics guidelines Rui LIU, Ying LIU, Mei-jing LAN, Niusha TAHERI, Jing-li CHENG, Yi-rong GUO, and Guo-nian ZHU declare that they have no conflict of interest. All institutional and national guidelines for the care and use of laboratory animals were followed. 10.1631/jzus.B1500278 Project supported by the Special Fund for Agro-scientific Research in the Public Interest (No. 201203094-3), the Scientific Research Fund of Zhejiang Provincial Education Department (No. Y201329970), the National Natural Science Foundation of China (No. 31401768), and the Experimental Technology Research Project of Zhejiang University (No. SZD201404), China 2015-11-11 2016-03-13 2015-12-28 2022-01-05 Copyright © Zhejiang University and Springer-Verlag Berlin Heidelberg 2016 2016 Journal of Zhejiang University-SCIENCE B (Biomedicine and Biotechnology) 04 17